House built ‘for the big one’ stands amid Mexico Beach devastation

MEXICO BEACH, Fla. (AP/WSVN) — Unlike in South Florida, homes in the state’s Panhandle did not have tighter building codes until just 11 years ago; it was once argued that acres of forests would provide the region with a natural barrier against the savage winds of a hurricane.

Many of those structures did not withstand the fury of Hurricane Michael, which slammed into the area last week with winds of up to 155 mph, leaving acres of flattened houses and other buildings in its wake before roaring across the Georgia border inland.

“We’re learning painfully that we shouldn’t be doing those kinds of exemptions,” said Don Brown, a former legislator from the Panhandle who now sits on the Florida Building Commission. “We are vulnerable as any other part of the state. There was this whole notion that the trees were going to help us, take the wind out of the storm. Those trees become projectiles and flying objects.”

But amid the ruins, one home in the devastated town appeared mostly unscathed by the storm.

The three-story home stands on 40-foot pilings, and its owners told CNN it was designed to survive “the big one.”

“At every point, from pilings to the roof and everything in between, when it came time to make a decision about what level of material or what to use, we didn’t pay attention to code,” Lebron Lackey told CNN. “We went above and beyond code, and we asked the question: ‘What would survive the big one?’ And we consistently tried to build it for that.”

Hurricane Andrew a generation ago razed Florida’s most-populated areas with winds up to 165 mph, damaging or blowing apart more than 125,000 homes and obliterating almost all mobile homes in its path. The acres of flattened homes showed how contractors cut corners amid the patchwork of codes Florida had at the time. For example, flimsy particle board was used under roofs instead of sturdier plywood, and staples were used instead of roofing nails.

Since 2001, structures statewide must be built to withstand winds of 111 mph and up; the Miami area is considered a “high velocity hurricane zone” with much higher standards, requiring many structures to withstand hurricane winds in excess of 170 mph.

Lackey and his uncle, Russell King, went beyond even South Florida’s more stringent code requirements, building their home to withstand winds as high as 250 mph.

“We wanted to build it for the big one,” Lackey told the New York Times. “We just never knew we’d find the big one so fast.”

The home, nicknamed the “Sand Palace,” has walls made of concrete with rebar throughout. They even took some windows out and replaced them with concrete, thus limiting their beach view.

“A lot of people criticized this. Our friends said, why didn’t you put more windows in? We did put the gulf view in, but the rest of it, not so much,” King said.

“I could have put a balcony that I wanted on the east side of the house,” he continued. “The engineer said, I thought you wanted a hurricane house? We took it off. I wanted more overhang. He said, ‘I thought you wanted a hurricane house?’ So our (overhang) is very small.”

The home did suffer some damage: the stairs that go from the ground floor up to the rest of the house are gone, as well as windows in one of the bedrooms. Lackey and King say all of the utilities have to be redone, and noted there is some water damage.

Though Michael’s winds were particularly fierce, any boost in the level of safety requirements for builders could help homes better withstand hurricanes.

Tom Lee, a homebuilder and legislator, says past hurricanes have shown time and time again that the stricter codes help. He said after such previous storms, he could see during flyovers which homes were built before the new code.

“The structural integrity of our housing stock is leaps and bounds beyond what it was,” Lee said.

The codes call for shatterproof windows, fortified roofs and reinforced concrete pillars, among other specifications. But it wasn’t until 2007 that homes built in the Panhandle more than 1 mile from shore were required to follow the higher standards. Hurricane Michael pummeled the region with devastating winds from the sea all the way into Georgia, destroying buildings more than 70 miles from the shoreline.

Gov. Rick Scott said it may be time for Florida to boost its standards — considered the toughest in the nation— even further.

“After every event, you always go back and look what you can do better,” Scott said. “After Andrew, the codes changed dramatically in our state. Every time something like this happens, you have to say to yourself, ‘Is there something we can do better?'”

Mexico Beach, the Gulf Coast town destroyed by Michael, lacked a lot of new or retrofitted construction, said Craig Fugate, the former director of the Federal Emergency Management Agency and a former emergency management chief for the state of Florida. The small seaside community had a lot of older mobile homes and low-income year-round residents working in the commercial fishing and service industries.

“Quiet, idyllic, what I call ‘Old Florida,'” Fugate said. “This is not a bunch of high rises or brand new developments.”

Bill Herrle, who owned a house near the shoreline in Mexico Beach until it was destroyed by the storm, said he wasn’t sure it made a difference when the homes there were built. He said the storm took out his house, built in the mid-’80s, as well as newer buildings put up recently.

“It wiped out both the older and newer homes. It looks like my entire street is razed,” said Herrle, who was not in Mexico Beach during the storm.

David Prevatt, an associate professor of civil and coastal engineering at the University of Florida, said in an email Thursday that drone footage of the devastation in Mexico Beach showed structural damage to roofs and exterior walls, and damaged rafters and trusses, “indicating the strength of the wind that caused those failures.”

Prevatt noted the damage could have occurred at wind speeds lower than the 155 mph that the National Hurricane Center reported at Michael’s landfall. That is, the homes could have been peeling apart before the eye and the hurricane’s strongest core winds came ashore.

Prevatt was preparing to lead a team to assess the damage. He said engineers will be asking how old the destroyed and damaged buildings were and under what version of the Florida building codes they were built. They also will be looking at the differences between the structures that survived and those that did not.

Copyright 2018 The Associated Press. All rights reserved. This material may not be published, broadcast, rewritten or redistributed.